OSHA'S HAZARD COMMUNICATION STANDARD
U.S. DEPARTMENT OF LABOR
29 CFR 1910.1200 OMB NO: 1218-0072
IDENTITY NO: STM3000,STM3032 NAME: LOW GLOSS SEAL & FINISH
SECTION 1
MANUFACTURER'S/SHIPPER'S NAME: IPT, INC.
ADDRESS: 4216 N. Pecos Road, Suite 102 PHONE: (702) 895-9865
CITY: LAS VEGAS STATE: NEVADA CONTACT: TOM COX
DATE PREPARED: 4/15/02 EMERGENCY PHONE (CHEMTREC): (800) 424-9300
SECTION 2 - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
HAZARDOUS COMPONENTS CAS# OSHA PEL ACGIH TLV WEIGHT %
ETHYLENE GLYCOL* 10721 50PPM 50PPM
NOTE: *A SARA 313 CHEMICAL
SECTION 3 - PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING POINT: >212F SPECIFIC GRAVITY: 1.02
VAPOR PRESSURE: NOT TESTED MELTING POINT: NOT TESTED
VAPOR DENSITY: NOT TESTED EVAPORATION RATE: NOT TESTED
SOLUBILITY IN WATER: 100% VOC CONTENT: 35.7 G/L
APPEARANCE AND ODOR: OPAQUE WHITE, BLAND ODOR
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: NONE FLAMMABLE LIMITS: NOT TESTED
LEL: NOT TESTED UEL: NOT TESTED
pH: 9.0-11.5 DOT#: NONE
NFPA HAZARD RATING H F R S
(O=LEAST, 4=EXTREME) 1 0 0 0
EXTINGUISHING MEDIA: NONE
SPECIAL FIRE FIGHTING PROCEDURES: NONE
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE
SECTION 5 - REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID: NONE
INCOMPATIBLE MATERIALS TO AVOID: STRONG OXIDIZERS
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: CO,CO2
HAZARDOUS POLYMERIZATION: NONE
SECTION 6 - HEATH HAZARD DATA
ROUTES OF ENTRY:
INHALATION: POSSIBLE INGESTION: POSSIBLE
SKIN: POSSIBLE HEALTH HAZARDS: SAME SIGNS & SYMPTOMS OF EXPOSURE
OSHA CARCINOGENICITY: NONE NTP: NONE IARC MONOGRAPHS: NONE
SIGNS & SYMPTOMS OF OVER EXPOSURE:
EYES: BURNING SENSATION SKIN: SLIGHT IRRITATION
INGESTION: IRRITATION INHALATION: NOT EXPECTED TO BE A PROBLEM
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: SAME AS SIGNS & SYMPTOMS OF
OVER EXPOSURE.
EMERGENCY FIRST AID PROCEDURES:
EYES: FLUSH WITH WATER FOR 15 MINUTES. IF IRRITATION PERSISTS CALL PHYSICIAN.
SKIN: WASH WITH SOAP AND WATER, ESPECIALLY BETWEEN NAILS. IF IRRITATION PERSISTS CALL
PHYSICIAN.
INGESTION: DRINK LARGE AMOUNTS OF WATER. CALL PHYSICIAN
INHALATION: SEE ABOVE
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:SOAK UP WITH INERT
ABSORBENT MATERIAL. SWEEP UP AND PLACE IN A PROPER WASTE DISPOSAL CONTAINER.
WASTE DISPOSAL METHOD: DISPOSE OF IN ACCORDANCE WITH STATE AND LOCAL REGULATIONS.
PRECAUTIONS TO BE TAKEN IN HANDLING & STORING: STORE IN COOL,DRY PLACE OUT OF
DIRECT SUNLIGHT. DO NOT STORE BELOW 32F OR ABOVE 110F.
OTHER PRECAUTIONS: KEEP OUT OF REACH OF CHILDREN. FOLLOW DIRECTIONS ON THE
CONTAINER FOR PROPER USE OF THIS PRODUCT.
SECTION 8 - CONTROL MEASURES
RESPIRATORY PROTECTION: OPEN ALL DOORS & WINDOWS. EXPOSURES ABOVE THE TLV OR
PEL REQUIRE A NOISH APPROVED RESPIRATOR EQUIPPED FOR THE EXPOSURE OR SUITABLE
RESPIRATORY PROTECTION PER 29 CFR 1910-134.
VENTILATION: LOCAL EXHAUST: IF AVAILABLE SPECIAL: NONE
MECHANICAL: IF AVAILABLE OTHER: NONE
PROTECTIVE GLOVES: RUBBER, PLASTICS
EYE PROTECTION: GLASSES, GOGGLES
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: CHEMICAL RESISTANT CLOTHING
WORK HYGIENIC PRACTICES: USE COMMON SENSE AND CARE AROUND CHEMICALS. NEVER MIX
CHEMICALS. CONSULT SUPERVISOR FOR OTHER PRACTICES. ALL PRACTICES DEPEND ON YOUR
SPECIFIC BUSINESS. DIRECTIONS FOR USE ARE NORMALLY FOUND LABEL, WHICH WILL DICTATE
ENGINEERING & CONTROL MEASURES.
OTHER SPECIAL REQUIREMENTS: NONE